VHR560AT-5UG
VHR560AT-60J

主要產品：日本東方馬達，泰映TROY減速電機，韓國SPG小功率馬達，

韓國DKM減速電機,CPG晟邦 ...

: /

：蘭工

      :

減速機技術資料：

減速機轉軸是減速機的重要零件之一，它是傳遞扭矩、帶動機械負載的主要部件。減速機軸必須有足夠的機械強度和剛度，才能完成減速機功率的傳遞，使減速機運行時不發生振動或定子、轉子相擦。

軸常見的損壞現象有：轉軸彎曲、軸頸磨損、軸裂紋和軸斷裂等。其損壞原因，除制造質量本身有問題外，大多數是使用不當造成的。例如，拆卸皮帶輪時，不用工具而硬敲，再加上敲打時受力不當，極易引起軸的損壞。

1．轉軸彎曲的修理轉軸彎曲會造成減速機氣隙不均，產生振動和噪聲。

若彎曲不大，為了消除彎曲對轉子鐵芯段的影響，可以磨光軸頸、滑環和換向器等。在小型異步減速機中，也可以磨光轉子的鐵芯段，但轉子與定子間增大的間隙值不應超過正常間隙的10％。

如果軸的彎曲值很大，以致不能用加工軸頸和軸上零件的方法來消除，可在壓力機上矯正，或用電焊機在彎曲處表面均勻堆焊一層，然后上車床，以轉子外圓為基準找出中心，車成要求尺寸，并用百分表檢查。

用敲打法矯正用冷態直軸法矯正轉軸的彎曲示意圖

2．軸頸磨損的修理軸頸磨損由于軸承內圈與軸頸的配合過盈過小，在運行中發生軸與內圈相對運動，使軸頸磨損而松動(即走內圓)。這時，必須將軸頸修補到原來尺寸。常用的修補方法有下列幾種：

方法～：噴鍍或刷鍍。利用專門的設備將金屬鍍在磨損的軸頸上，再磨削到需要的直徑。此法適用于磨損深度不超過0．2毫米的情況。

方法二：補焊。將轉軸放在帶滾輪的支架上，用中碳鋼焊條進行手工電弧焊，從一端開始，一圈一圈地補焊，邊焊邊轉動轉子，直至將軸頸全部補焊完畢。冷卻后，放到車床上加工到所需尺寸。加工時，注意校正兩軸頸與轉子外圓的同軸度。

方法三：鑲套。當軸頸磨損較大或局部燒損發藍退火時，可將軸頸車圓上后，放在車床上加工套的外圓。

3．軸裂紋或斷裂的修理對于出現裂紋的軸，若其裂紋深度不超過軸頸的10％～15％、長度不超過軸長的10％(對縱向而言)或不超過圓周長的10％(對橫向而言)，可用堆焊法進行補救。

對于裂紋大或斷裂的軸，必須更換新軸，換軸時，小型減速機一般用35號鋼或45號鋼。換軸一時有困難，在不影響軸質量的前提下，也可采用補接法

Johnson Metasys Control Devices

NEW! Eaton Cutler-Hammer Johnson Controls 60HP/75HP 480v AC Variable Speed Drive
480V 60HP CT / 75HP VT SVX9000 w/Inlidisconnect!

JOHNSON CONTROLS NU-NCM350-1 USPP NUNCM3501

JOHNSON CONTROLS METASYS NAE 5510-2 NICE PULL

JOHNSON CONTROLS NU-NCM350-8 USPP NUNCM3508

JOHNSON CONTROLS NU-XRL101-0 USPP NUXRL1010

JOHNSON CONTROLS MS-NAE4510-2 USPP AE45102

JOHNSON CONTROLS NU-NCM300-1 USPP NUNCM3001

Johnson Controls Electric Motor Variable Speed Drive 30 HP Eaton Cutler Hammer 

NEW! Eaton Cutler-Hammer Johnson Controls 60HP/75HP 480v AC Variable Speed Drive
480V 60HP CT / 75HP VT SVX9000 w/Inlidisconnect!

JOHNSON CONTROLS NU-NCM300-700 USPP NUNCM300700

Johnson Controls MS-MIG3120-0 Metasys Integrator

Johnson Controls MS-NAE 5511-1

JOHNSON CONTROLS MS-NAE5511-0 USPP AE55110

JOHNSON CONTROLS NU-DCM140-0 USPP NUDCM1400

New Johnson Network Controller, 8 meg, DRAM NU-NCM350-8, In Original Packaging

JOHNSON CONTROLS JNCA NSFP JNCA

JOHNSON CONTROLS METASYS MS-NAE4510-2 NEW IN BOX

Johnson Control MMS22300T1A Smart Screen Logic Unit - NEW

JOHNSON CONTROLS META NETWORK CONTROLLER NU-NCM311-0 #K298

Conrad Johnson Vacuum Tube ET3 Pre-Amp with Phono Input, with Remote Control

JOHNSON CONTROLS DVN-3000-NET-E?S USPP DVN3000NETES

Johnson Controls Metasys NU-NCM350-8 NCM-350 Controller NUNCM3508 New

JOHNSON CONTROLS METASYS NAE 4510-2 NICE PULL

JOHNSON CONTROLS AS-AHU-101-1 NSPP ASAHU1011

Conrad Johnson Vacuum Tube ET3 Line Pre-Amplifier with Remote Control

JOHNSON CONTROLS FA-DX9100-8454 USPP FADX91008454

JOHNSON CONTROLS TRS-102-2 NSFP TRS1022

JOHNSON CONTROLS MS-NAE3521-2 USPP AE35212

JOHNSON CONTROLS AS-AHU-101-1 USPP ASAHU1011

JOHNSON CONTROLS AS-AHU-101-0 USPP ASAHU1010

JOHNSON CONTROLS FIC-101-701 NSFP FIC101701

JOHNSON CONTROLS NU-NCM200-0 USPP NUNCM2000

Johnson Controls Electric Motor Variable Speed Drive 7.5 HP Eaton Cutler Hammer 

Johnson Controls Cutler Hammer Inlipass Frequency Drive VS030411A N0000

JOHNSON CONTROLS AS-AHU103-300 NSFP ASAHU103300

Johnson Controls Network Control Module NU-NCM201-701

JOHNSON CONTROLS METASYS NAE5510-0 USED WORKING PULL

JOHNSON CONTROLS AS-MIG201-0 USPP ASMIG2010

JOHNSON CONTROLS METASYS META NETWORK CONTROLLER NU-NCM311-1 #K299

JOHNSON CONTROLS MS-N301310-1 NSFP 3013101

JOHNSON CONTROLS FIC-101-701 USPP FIC101701

JOHNSON CONTROLS NU-XRE101-0 NSFP NUXRE1010

JOHNSON CONTROLS TRS-102-2 *NEW IN A BOX*

JOHNSON CONTROLS FIC-101-701 *NEW IN A BOX*

JOHNSON CONTROLS NU-XRL101-700 NSFP NUXRL101700

Johnson Controls Metasys NAE4511-1 Controller

Johnson Controls FM-OAP121-0 (Pack of 6) FMOAP1210 Function Module - Surplus

JOHNSON CONTROLS NU-DCM101-0 USPP NUDCM1010

JOHNSON CONTROLS MS-N301010-0 USPP 3010100

JOHNSON CONTROLS MS-N301310-1 USPP 3013101

JOHNSON CONTROLS NU-DCM101-700 USPP NUDCM101700

Johnson Controls NU-NCM101-0 NUNCM1010 Module - Used

Johnson Controls AS-AHU101-1 ASAHU1011 Controller Board Rev. H - Used

JOHNSON CONTROLS NU-XRE101-0 USPP NUXRE1010

JOHNSON CONTROLS PCR-102 USPP PCR102

Johnson Controls Electric Motor Variable Speed Drive 3 HP Eaton Cutler Hammer 55

Johnson Controls Metasys NCE2560 Controller NIB

JOHNSON CONTROLS MS-N301310-0 USPP 3013100

Johnson Controls Metasys MS-MIG3120-0 Integrator Controller MSMIG31200 New

JOHNSON CONTROLS METASYS NAE4520-2 BAS CONTROLLER NIB

JOHNSON CONTROLS METASYS MS-NAE4510-0 USED WORKING PULL NICE CONDITION

Johnson Controls NU-NCM201-1 NUNCM2011 Network Communication Module - Used

NEW JOHNSON CONTROLS METASYS NU-DCM140-0 DIGITAL CONTROL MODULE 

OEM Trane American Standard Johnson Controls Variable Control Board VFD66JCB-1C

OEM Trane American Standard Johnson Controls Variable Control Board VFD66KCB-1C

Conrad Johnson Classic Vacuum Tube Line Pre-Amplifier , No Remote Control 

JOHNSON CONTROLS EN-BSF201-0 NSFP ENBSF2010

NEW JOHNSON CONTROLS METASYS AS-AHU101-1 MOUNTING ENCLOSURE FIELD WIRING TERMINA

JOHNSON CONTROLS NU-XBN101-0 USPP NUXBN1010

SEALED Johnson Controls AS-AHU101-0 Mounting Enclosure / Wiring Termination Assy

Johnson Controls NQ-6100-1 2 Stage Master Panel

NEW JOHNSON CONTROLS METASYS NU-XRM101-0 BINARY INP/OUT MODULE 

Johnson Controls NU-DCM140-0 NUDCM1400 Output Module Digital Control - Used

JOHNSON CONTROLS FIC-101-1 USPP FIC1011

JOHNSON CONTROLS DX-9120-8454 USPP DX91208454

Johnson Controls NU-NCM101-0 NUNCM1010 Module - Damaged Face Hinge - Used

JOHNSON CONTROLS METASYS MS-NAE3510-1 NICE USED WORKING PULL

Johnson Controls NU-NCM101-700 NUNCM101700 Module Rev. H - Used

JOHNSON CONTROLS MS-MIG3120-0 NEW

New Johnson Controls AS-AHU101-0 Mounting Enclosure / Wiring Termination Assy

JOHNSON CONTROLS DA-3000-7611 USPP DA30007611

JOHNSON CONTROLS SVX007A1-4A1B1 AC DRIVE 380-500V ***XLNT***
 within 60 days
Johnson Controls NU-XRE101-0 NUXRE1010 Module - Used

JOHNSON CONTROLS RZ45002 USPP RZ45002

JOHNSON CONTROLS METASYS DX9100-8454 NEW IN OPEN BOX NO WIRING BASE

Johnson Controls NCE2566-0 NIB

Johnson Controls MS-NAE5521-0

Johnson Controls NCE2510-0 NIB

Johnson Controls EP Transducer, P/N N-6800-5, NSN 6685-00-932-10?97

JOHNSON CONTROLS METASYS EN-BSF101-0 W/ NU-PWR101-700

* EATON CUTLER-HAMMER / JOHNSON CONTROLS VARIABLE SPEED DRIVE/AC SVX015A1-4A1B1

Johnson Controls DIGITAL VARIABLE AIR VOLUME TERMINAL UNIT CONTROL C210A-1

Johnson Controls EN-BSF201-0 2-Slot Base Frame

Johnson Controls Metasys AS-AHU101-0 Control 

JOHNSON CONTROLS MQ-LDT1100-0 NSPP MQLDT11000

JOHNSON CONTROLS METASYS MS-MIG3120-0G INTEGRATOR UWP

JOHNSON CONTROLS S300-RDR2 NSFP S300RDR2

Johnson Controls LP-FXA-C-0 Facility Explorer 

Johnson Controls AS-AHU101-0 MetaSys DDC Controller ASAHU1010

Johnson Controls Circulated Air ( PE-FEU-DCA111)

NEW! Eaton Cutler-Hammer Johnson Controls 6HP/7.5HP 480v AC Variable Speed Drive
480V 6HP CT / 7.5HP VT SVX9000 w/Inlidisconnect!

JOHNSON CONTROLS METASYS N30 CONTROLLER MS-N301310-1 - USED - 1 YR RETURN POLICY

 within 60 days
NEW JOHNSON CONTROLS METASYS NU-DCM140-0 DIGITAL CONTROL MODULE 

JOHNSON CONTROLS S300-IO8 NSFP S300IO8

JOHNSON CONTROLS DT-9100-8104 NSFP DT91008104

JOHNSON CONTROLS MQ-LDT1100-0 USPP MQLDT11000

johnson controls WAT70 H2K15501BL

NEW JOHNSON CONTROLS METASYS NU-XRL101-700 BINARY MODULE NUXRL101700 

Johnson Control PANEL FEC 2610-0 Controller 24 X 36 PAKAJD002BH0

JOHNSON CONTROLS N-6820-1 NSPP N68201

JOHNSON CONTROLS PAKG00001FH0 NSFP PAKG00001FH0

Air Conditioning Transducer RY10417/ N-6800-5 Johnson Controls Appears Unused

Johnson Controls Temperature Controller A350AA-1 Lot of 17 Used Working
 within 60 days
Used Lighting and HVAC control System, GE & Johnson Controls

JOHNSON CONTROLS CEB-104-0 NSFP CEB1040

JOHNSON CONTROLS VFC-050HB-723D USPP VFC050HB723D

Johnson Controls LP-FXA-C-0 Facility Explorer 

NEW JOHNSON CONTROLS METASYS EN-BSF201-0 2-SLOT BASE FRAME ASSBEMBLY

JOHNSON CONTROLS METASYS NU-XRM101-0 BINARY INP/OUT MODULE 

Johnson controls EN-BSF101-0 & NU-NCM200-0 & PWR101

Johnson Controls METASYS NU-NCM201-1 & NIM 206-1

JOHNSON CONTROLS M130-G-GA-3 NSFP M130GGA3

Johnson Controls Metasys NU-NCM300-1 NCM-300 Controller W/Enclosure NUNCM3001

Johnson Controls LP-FXA-EXTOC-0 Reg:G Facility Exp. 

JOHNSON CONTROLS 24-4548-2 USPP 2445482

JOHNSON CONTROLS M150JGA-1 NSFP M150JGA1

1989 150hp Johnson V6 Outboard Motor w/Controls Titled Still on Boat Running!

M130GGA-3 Johnson Controls Rotary Actuator M130GGA3 

JOHNSON CONTROLS AS-AHU-102-0 NSFP ASAHU1020

JOHNSON CONTROLS S-7300-3 USPP S73003

JOHNSON CONTROLS M150GGA-3 NSFP M150GGA3

JOHNSON CONTROLS METASYS EN-BSF101-0 1 SLOT BASE & MODS

JOHNSON CONTROLS METASYS NU-NCM350-8 WORKING PULL

JOHNSON CONTROLS CEB-104-0 NSPP CEB1040

Johnson Controls Metasys NU-NCM350-1 NCM-350 Controller NUNCM3501

Johnson Controls Metasys NU-NCM350-8 NCM-350 Controller

JOHNSON CONTROLS VG7844ST NSFP VG7844ST

JOHNSON CONTROLS 24-4548-2 *NEW NO BOX*

Johnson Controls Metasys AS-AHU101-0
Make me an offer im looking to get it out of here!

Johnson Controls Metasys NU-NCM300-1 NCM-300 Network Controller NUNCM3001

JOHNSON CONTROLS VFD66DAA8C NSFP VFD66DAA8C

JOHNSON CONTROLS M110AAB-1 NSFP M110AAB1

JOHNSON CONTROLS M130-J-GA-1 NSPP M130JGA1

Johnson Controls D350AA-1 Display & S350AA-1 Stage Module lot of 14 working
 within 60 days
Johnson Controls LP-FX15D71-000?C FX15 Field Controller Facility Explorer Panel

NEW - Johnson Controls NCE2516 With Display

JOHNSON CONTROLS REGULATED POWER SUPPLY RPA-105-1 40VAC

Johnson Controls MM-CPNLTD-0 Companion Controller New 

FOUNDRY JOHNSON CASTING FURNACE WITH CONTROLLER

Enlarge
JOHNSON CONTROLS NCM300 METASYS NU-NCM300-1 REV B NETWORK CONTROLLER 

JOHNSON CONTROLS/METAS?YS NU-XRE101-0 CONTROLLER ! BNIB

NEW JOHNSON CONTROLS METASYS AS-AHU-101-0 DDC CONTROLLER 

Johnson Controls Inc. / Penn - 1 1/4" Fluid Pressure Regulating Flanged Valve 

Johnson Controls Metasys NU-NCM350-701 NCM-350 Controller NUNCM350701

Johnson Controls Metasys NU-NCM350-8 NCM-350 Controller

JOHNSON CONTROLS M130-G-GA-3 NSPP M130GGA3

Lot of 12 NEW Johnson Controls V-3766-1002 Valves V37661002

JOHNSON CONTROLS T-5800-2 *SEALED* 

JOHNSON CONTROLS N500AAA-1 NSFP N500AAA1

JOHNSON CONTROLS EPT-102-1 NSFP EPT1021

Johnson Controls Metasys MS-MIG3120-0 Integrator Controller MSMIG31200

Johnson Controls Metasys MS-N301310-1 N30 Controller 3013101

Johnson/Evinru?de OMC Rigging Kit Remote Control, Oil Tank, Wire Harness, 763849

JOHNSON CONTROLS C-7351-2 NSFP C73512

JOHNSON CONTROLS METASYS AS-LCP200-0 CONTROLLER NEW IN BOX OLD STOCK

JOHNSON CONTROLS DX-9100-8454 USPP DX91008454

JOHNSON CONTROLS M150JGA-1 NSPP M150JGA1

JOHNSON CONTROLS M110GGA-1 NSFP M110GGA1

JOHNSON CONTROLS 24-8478-4 USPP 2484784

Johnson Controls M130JGA-1 Actuator Proportional New IB

JOHNSON CONTROLS IO-NTU102-0 USPP IONTU1020

JOHNSON CONTROLS EATON 10HP FREQUENCY DRIVE

Johnson Controls M130AAB-1 ON-OFF Rotary Actuator NEW

Johnson Controls Metasys Facilitator FA-N311310-1 N31 Controller FAN3113101

NEW JOHNSON CONTROLS CONTROL BOARD METASYS AIR HANDLING AS-AHU-102-0

JOHNSON CONTROLS CEB-104-0 USPP CEB1040

JOHNSON CONTROLS SVX002A1-2A1B1 VARIABLE SPEED DRIVE ***XLNT***
 within 60 days
Johnson Controls M140GGA-3 Rotary Actuator 24VDC ! NEW !

Johnson Controls Metasys AS-AHU101-1 AHU Controller ASAHU1011

JOHNSON CONTROLS C-7351-2 NSPP C73512

JOHNSON CONTROLS DC-9100-8004/5?4 USPP DC9100800454

JOHNSON CONTROLS M130-J-GA-1 USPP M130JGA1

JOHNSON CONTROLS AS-UNT111-101 USPP ASUNT111101

JOHNSON CONTROLS 031-01579-000 USPP

Belimo DN50 Valve With Johnson Controls M2215-HGA-2 Actuator NEW

Johnson Controls Power Supply Unit Type# DSC-8500!

Johnson Controls NIE5511-0

Johnson Controls MS-NAE3510-2

1 NEW JOHNSON CONTROLS F63FF-2C FLOAT SWITCH NIB

JOHNSON CONTROLS DX LCD DISPLAY DT-9100-8004 L9936

Johnson/Evinru?de/OMC New Dual Lever Binnacle Remote Control Twin Engine 5006184

Johnson Controls Series M100J Proportional Motor Actuator (M130JGA-1) ** NEW

Johnson Controls Meta Sys Set # NCM200, NU-NCM200-0, EN-BSF1210, NU-PWR-101-0 

AS-UNT-1126-0 JOHNSON CONTROLS UNT1100 Series Unitary Controller NEW

Johnson Controls C-7351-2 Seven Day Timer

JOHNSON CONTROLS M130-G-GA-3 USPP M130GGA3

Johnson Controls DX-9100-8454 Digital Controller 

Notifier ( Johnson Control ) JCPU-2020 FACP 

JOHNSON CONTROLS MS-FEC2621-0 NSFP MSFEC26210

JOHNSON CONTROLS CIB-104 *NEW NO BOX*